| 耐酸胶泥施工应按下列技术规程进行 |
| 添加时间：2018/3/9 14:01:45 浏览次数： |
| 耐酸胶泥施工应按下列技术规程进行. The construction of acid resistant mud should be carried out according to the following technical regulations. 一、材料配合比(重量) Material mix (weight) 胶泥粉:水玻璃=100:36-40 Mud powder: water glass =100:36-40 按上述配合比应根据全国各地施工现场的气侯、温度、湿度进行现场调试，调试到适合现场施工的比例再进行施工. According to the above mix proportion, we should debug the site according to the climate, temperature and humidity of the construction site throughout the country, and debug the proportion that is suitable for the field construction, and then proceed with the construction. 二、材料用量：在基础面符合平整度要求的情况下每平方用量15-18KG Two, material dosage: per square amount of 15-18KG under the condition that the base meets the requirement of flatness 三、工前要做好衬砌基体的除锈、除油、除污工作.水泥基层的含水率不大于6%，并注意修整凹凸不平部位，并使之干燥. Three, before work, rust removal, deoiling and decontamination work of lining base should be done well. The moisture content of cement base is not greater than 6%, and attention should be paid to trimming the uneven parts and making them dry. 四、在用人工搅拌时，应用方头小号铁锹，把按比例称好的胶泥粉和水玻璃充分搅和均匀，应有足够的稠度和流动性，并在30分钟内用完. Four, in the use of artificial mixing, the application of the uniform square small shovel, fully mix the clay powder and weighed according to proportion of water glass, with sufficient consistency and liquidity, and run out in 30 minutes. 五、施工现场温度应介于15℃-33℃，相对湿度应不大于75%,露天施工应搭防雨防晒棚. Five. The temperature of the construction site should be between 15 and -33 C, and the relative humidity should not be more than 75%. The rain proof sunscreen should be taken in the open air construction. 六、在砌衬砖板时，胶泥应饱满，并用橡皮锤震击不平处使之平整.砌大砖时应予支撑防止移位， In six, lining brick, mortar should be full, and with a rubber hammer hammer to smooth uneven shock. When the brick masonry should be supported to prevent movement, 七、衬好的设备地面，地坪应以最后一层的砌筑时间在大于15℃的环境中养护14天，养生期间严禁与水和水蒸气接触. 养生后的耐酸胶泥在使用前须用耐酸胶泥特种处理液稀硫酸（30%浓度的盐酸）4次，每隔8小时处理一次。 Seven, the ground floor lining equipment, should be based on the time of the last layer in the building of more than 15 degrees Celsius in the environment of health during the curing 14 days, with no water and water vapor contact. After curing acid resisting clay must be used for special treatment of liquid acid clay before using dilute sulfuric acid (concentration of 30% hydrochloric acid) 4 times. Every 8 hours. 八、注意水玻璃一定要按比例加入，不能多加！另在耐酸砖铺砌及沟缝施工过程中必须保证胶泥不往耐酸砖上粘，否则施工完后再去清理会费时费工还清不掉，最后影响验收。 Eight, pay attention to the water glass must be proportionate, not more! In the other acid resistant brick paving and seam construction process must not to stick clay tiles, or after the construction to take off work cleaning off, finally affect the acceptance. |
| 上一页 耐酸水泥的定义及使用配方 |
| 下一页 耐酸胶泥在烟囱防腐中的作用 |
Copyright © 技术支持：遨游网络